FGDF7105,10*1D,2D
Installation/Care/Use Manual
USES HFC-134A REFRIGERANT
SEE FIG. 4
7
SEE FIG. 3
30
27
13
14
25
15
23
17, 18, 19, 20
28
24
16
21, 22, 31
8, 9, 29
26
FIG. 1
PAGE 1
97334C (Rev. H - 12/04)
FGDF7105,10*1D,2D
FINISHED FLOOR
PISO ACABADO
PLANCHER FINI
FIG. 2
LEGEND/LEYENDA/LÉGENDE
A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB 1-1/2" (38mm) OUT
FROM WALL SHUT OFF BY OTHERS
SE RECOMIENDA UBICAR EL TUBO DE CONEXIÓN AL TUBO DE COBRE SIN CHAPAR DE 3/8" DE DIAM. EXT. A 1-1/2" (38mm)
FUERA DE LA LLAVA DE PASO EN LA PARED COLOCADA POR TERCEROS.
EMPLACEMENT RECOMMANDÉ D’ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5mm) D.E.
CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38mm) DEPUIS LE ROBINET D'ARRET FOURNI PAR D'AUTRES.
B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4” O.D. DRAIN
UBICACIÓN RECOMENDADA PARA EL DRENAJE DE SALIDA DE AGUA, DE 1-1/4" DE DIÁMETRO.
EMPLACEMENT RECOMMANDÉ POUR LE DRAIN DE D.E. 1-1/4" DE SORTIE D’EAU.
C = 1-1/4 TRAP NOT FURNISHED
PURGADOR DE 1-1/4 NO PROPORCIONADO
SIPHON 1-1/4 NON FOURNI
D = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.
ASEGURE UNA VENTILACIÓN ADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.) DE HOLGURA ENTRE LA REJILLA
DE VENTILACIÓN DEL MUEBLE Y LA PARED
ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.) ENTRE LES ÉVENTS DE L’ENCEINTE ET LE MUR.
E = POWER CORD 4 FEET (1219mm) LONG
CABLE ELÉCTRICO DE 4 PIE (1219mm), DE LARGO
CORDON D’ALIMENTATION 4' (1219mm)
97334C (Rev. H - 12/04)
PAGE 2
FGDF7105,10*1D,2D
Note: When installing replacement bubbler and pedestal, tighten nut (Item 12)
only to hold parts snug in position. Do not over tighten.
10
11
12
FIG. 3
Stream height is factory set at 35 PSI. If supply pressure varies greatly from this,
remove Items 1 & 2 and adjust screw on Item 4. Clockwise adjustment will raise
stream and counter-clockwise adjustment will lower stream. For best adjustment,
stream should hit basin approximately 6-1/2" (165mm) from bubbler.
1
2
3
4
5
BASIN
6
FIG. 4
PAGE 3
97334C (Rev. H - 12/04)
FGDF7105,10*1D,2D
PARTS LIST 230V-50/60Hz
PARTS LIST 115V
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
1
2
3
4
5
6
7
8
8
40089C
40048C
15005C
61313C
40169C
50986C
22543C
36176C
31025C
31039C
36181C
35935C
98118C
100322740560
15009C
55996C
66504C
66505C
31513C
31501C
31490C
30664C
70018C
20282C
50144C
19037000
66200C
66202C
66300C
66302C
66508C
66303C
66305C
20460C
21482C
21239C
21486C
35786C
35767C
35947C
31797C
31797C
35768C
56092C
75670C
Cover
Button
Regulator Retaining Nut
Regulator
Hex Nut
Regulator Holder
Basin & Precooler assy
Overload (5 GPH)
Overload/Relay Assy 1.350.358 (10 GPH)
Overload/Relay Assy P600B/427NFBYY(10 GPH)
Relay (5 GPH)
Capacitor - Run
Bubbler Assembly
Washer
Bubbler Nipple
Strainer
Evaporator Assy (5 GPH)
Evaporator Assy (10 GPH)
Cold Control
Power Cord
Fan Motor
Fan Blade
Fan Blade Nut
Fan Motor Bracket
Grommet - Compressor Mtg.
Clip - Compressor Mtg.
Drier (5 GPH)
Drier (10 GPH)
Heat Exchanger (5 GPH)
Heat Exchanger (10 GPH)
Heat Exchanger (10 GPH)
Condenser (5 GPH)
Condenser (10 GPH)
Front Panel (Stainless Steel)
Front Panel (Sandalwood)
Cabinet (Stainless Steel)
Cabinet (Sandalwood)
Compressor Serv. Pak PW3HK7 (5 GPH)
Compressor Serv. Pak FF7.5HBK (10GPH)
Compressor Serv. Pak EM65 (10GPH)
Cover - Relay
Cover - Relay
Cover - Relay
Poly Tubing (Cut to Length)
Stud - Compressor Mtg.
8
31035C
36195C
36050C
31505C
31430C
35788C
36085C
35768C
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
24a
24b
25
26
27
28*
28a*
28b*
29
29a
29b
30
31
16
17
*28
29
DESCRIPTION
Overload/Relay Assy (5 GPH)
Overload (10 GPH)
Relay (10 GPH)
Power Cord
Fan Motor
Compressor Serv Pak (5 GPH)
Compressor Serv Pak (10 GPH)
Relay Cover (10 GPH)
*REPLACE WITH SAME COMPRESSOR USED IN ORIGINAL ASSEMBLY.
NOTE: All correspondence pertaining to ELKAY water coolers or orders
for repair parts MUST include Model No. and Serial No. of cooler, name
and part number of replacement part.
PRINTED IN U.S.A.
FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620
REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640
ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484
97334C (Rev. H - 12/04)
PAGE 4
">
